Organic Syntheses, Coll. Vol. 2, p.108 (1943); Vol. 16, p.7 (1936).
In a 3-l. three-necked, round-bottomed flask
, fitted with a mechanical stirrer (Note 1)
, a separatory funnel
extending to the bottom of the flask, and a thermometer
, are placed 380 g. (5.5 moles) of c.p. sodium nitrite
and 1.5 l. of water. The flask is surrounded by an ice-salt mixture, and the solution is stirred until the temperature falls to 0°. A mixture of 100 cc. of water, 136 cc. (250 g., 2.5 moles) of concentrated sulfuric acid
(sp. gr. 1.84) (Note 2)
, and 457 cc. (370 g., 5 moles) of commercial n-butyl alcohol
is cooled to 0° and by means of the separatory funnel is introduced slowly beneath the surface of the nitrite solution, with stirring. The alcohol solution is added slowly enough so that practically no gas is evolved, and the temperature is kept at ±1°. This usually requires from one and one-half to two hours.
The resulting mixture is allowed to stand in the ice-salt bath
until it separates into layers, and the liquid layers are decanted from the sodium sulfate
into a separatory funnel (Note 3)
. The lower aqueous layer is removed and the butyl nitrite
layer washed twice with 50-cc. portions of a solution containing 2 g. of sodium bicarbonate
and 25 g. of sodium chloride
in 100 cc. of water. After drying over 20 g. of anhydrous sodium sulfate
, the yield of practically pure butyl nitrite
amounts to 420–440 g.
per cent of the theoretical amount) (Note 4)
and (Note 5)
. If desired, the product may be distilled under reduced pressure when 98
per cent distils at 24–27°/43 mm. (Note 6)
. Butyl nitrite
boils at 75°
under atmospheric pressure, with some decomposition.
A stirrer capable of keeping solid material in motion and driven by a strong motor
should be used because of the precipitation of large amounts of sodium sulfate
towards the end of the reaction.
If more butyl nitrite
separates from the sodium sulfate
after the first decantation, a second decantation is made. Care must be exercised in handling butyl nitrite
; inhalation of the vapor may cause severe headache and heart excitation.
The same procedure is quite satisfactory for runs of one-tenth this size. In small runs mechanical stirring is unnecessary since gentle rotation of the flask by hand gives good mixing.
may be made in the same manner and with approximately the same yields.
decomposes slowly on standing and should be kept in a cool place and used within a few days or, at most, a few weeks after it is prepared. A sample which stood for five months during a warm summer seemed to contain only 20–25
per cent of the original nitrite. The products of decomposition consist of oxides of nitrogen
, water, butyl alcohol
, and polymerization products of butyraldehyde
This preparation is referenced from:
Copyright © 1921-, Organic Syntheses, Inc. All Rights Reserved